- Manuals
- Brands
- Cub Cadet Manuals
- Utility Vehicle
- Big Country 640
- Operator's manual
6x4 utility vehicle
Hide thumbs Also See for Big Country 640:
- Operator's manual (20 pages) ,
- Operator's manual (20 pages)
-
- Contents
- Table of Contents
- Troubleshooting
- Bookmarks
Table of Contents
-
Table of Contents
-
Important Safe Operation Practices
-
Slope Operation
-
Brake Pedal
-
-
Know Your Utility Vehicle
-
Ignition Switch
-
Hour Meter
-
-
Operating Your Utility Vehicle
- Servicing Your Utility Vehicle
-
Tire Pressure
-
Drive Belt
-
Adjusting Brake
-
- Service Chart
-
Accessories
- Specifications
- Troubleshooting
-
Commercial Warranty
-
Residential Warranty
Advertisem*nt
Quick Links
- 1 Know Your Utility Vehicle
- 2 Operating Your Utility Vehicle
- 3 Servicing Your Utility Vehicle
- 4 Service Chart
- 5 Specifications
- 6 Troubleshooting
- Download this manual
Operator's Manual
IMPORTANT: READ SAFETY RULES AND INSTRUCTIONS CAREFULLY
Warning:
This unit is equipped with an internal combustion engine and should not be used on or near any unimproved forest-
covered, brush-covered or grass-covered land unless the engine's exhaust system is equipped with a spark arrester meeting
applicable local or state laws (if any). If a spark arrester is used, it should be maintained in effective working order by the operator.
In the State of California the above is required by law (Section 4442 of the California Public Resources Code). Other states may have
similar laws. Federal laws apply on federal lands. A spark arrester for the muffler is available through your nearest engine authorized
service dealer or contact the service department, P.O. Box 368023 Cleveland, Ohio 44136-9722.
CUB CADET LLC P.O. BOX 361131 CLEVELAND, OHIO 44136-0019
PRINTED IN U.S.A.
6x4 Utility Vehicle
Model 640
769-00078H.fm
FORM NO.
(1/05)
Table ofContents
Advertisem*nt
Table of Contents
Related Manuals for Cub Cadet Big Country 640
-
Utility Vehicle Cub Cadet Big Country 640 Operator's Manual
6x4 utility vehicle (20 pages)
-
Utility Vehicle Cub Cadet 640 Operator's Manual
6x4 (20 pages)
-
Big country 6x4 utility vehicle (24 pages)
-
Utility Vehicle Cub Cadet 642 Operator's Manual
6x4 (22 pages)
-
Utility Vehicle Cub Cadet Big Country 641 Operator's Manual
6x4 utility vehicle (24 pages)
-
Utility Vehicle Cub Cadet 641 Operator's Manual
6x4 (20 pages)
-
Utility Vehicle Cub Cadet 6X4 Shop Handbook
(329 pages)
-
Utility Vehicle Cub Cadet Big Country 420A Operator's Manual
4x2 utility vehicle (24 pages)
-
Utility Vehicle Cub Cadet Big Country 431D Operator's Manual
4x2 utility vehicle (24 pages)
-
Utility Vehicle Cub Cadet Big Country 2004 Technical Update
(15 pages)
-
Utility Vehicle Cub Cadet BIG COUNTRY 4X2 Service Manual
(38 pages)
-
Utility Vehicle Cub Cadet Challenger Series Service Manual
(256 pages)
-
Utility Vehicle Cub Cadet Volunteer Operator's Manual
(36 pages)
-
Utility Vehicle Cub Cadet Challenger Series Service Manual
(244 pages)
-
Utility Vehicle Cub Cadet Volunteer 4x4 EFI Operator's Manual
(28 pages)
-
Utility Vehicle Cub Cadet Challenger 400 Operator's Manual
(48 pages)
Summary of Contents for Cub Cadet Big Country 640
- Page 1 Federal laws apply on federal lands. A spark arrester for the muffler is available through your nearest engine authorized service dealer or contact the service department, P.O. Box 368023 Cleveland, Ohio 44136-9722. CUB CADET LLC P.O. BOX 361131 CLEVELAND, OHIO 44136-0019 769-00078H.fm PRINTED IN U.S.A.
-
Page 2: Table Of Contents
Customer Dealer Referral Line or an authorized service dealer. Copy the model number here: Copy the serial number here: CUB CADET LLC P. O. BOX 361131 www.cubcadet.com CLEVELAND, OH 44136... -
Page 3: Important Safe Operation Practices
SECTION 1: IMPORTANT SAFE OPERATION PRACTICES WARNING: This symbol points out important safety instructions which, if not followed, could endanger the personal safety and/or property of yourself and others. Read and follow all instructions in this manual before attempting to operate or service this vehicle. When you see this symbol - heed its warning. -
Page 4: Slope Operation
Children 25. Do not start or operate vehicle in an inside area, unless it is adequately ventilated. Engine exhaust 1. Tragic accidents can occur if the operator is not contains carbon monoxide fumes, which are very alert to the presence of children. Children are often poisonous and can be deadly. - Page 5 3. When manually raising cargo box, make sure truck or trailer bed with a plastic liner. Always Manual Support Lift Rod is securely locked before place containers on the ground away from leaning under raised cargo box. your vehicle before filling. 4.
- Page 6 WARNING WARNING • This is an off-road utility vehicle. Do not operate CARGO BOX AVOID INJURY WHEN on public highways. It handles and maneuvers differently than a normal passenger car. Sharp, LATCH USING CARGO BOX LIFT high speed turns or abrupt maneuvers can cause vehicle to roll over or go out of control.
-
Page 7: Know Your Utility Vehicle
SECTION 2: KNOW YOUR UTILITY VEHICLE NOTE: Reference to right or left hand side of the utility vehicle is observed from the operating position. Figure 1 Brake Pedal Read this operator’s manual, safety labels, and operating instructions on the vehicle before operating. The brake pedal is located on the left side of the floor Compare the illustrations in this manual with your unit beneath the dash panel. -
Page 8: Ignition Switch
12V Power Outlet • To engage the parking brake, push brake pedal down firmly, pull out on the parking brake latch, and The 12V power outlet is located on the right side of the release foot from brake pedal. Brake pedal will stay dash panel. -
Page 9: Hour Meter
Hour Meter Fuel Shut Off Valve The hour meter is located in the center of the warning The fuel shut off valve is located under the seat and it is light cluster. It reads the elapsed time engine has run. strapped onto the fuel tank. -
Page 10: Operating Your Utility Vehicle
WARNING: Do not exceed the vehicle’s Total Load Capacity of 1,400 lb., which Cargo Box includes driver, accessories, and cargo. Do not exceed 1000 lbs. in the cargo box. Tailgate The tailgate can be hinged at the top or the bottom depending on how you release the holding pins. - Page 11 Manual Lift WARNING: Do not stop or start suddenly when going uphill or downhill. Be especially NOTE: The manual lift and lower procedures should cautious when changing direction on slopes. only be done after cargo box is emptied. Apply brakes when going down slopes to maintain control of vehicle.
-
Page 12: Servicing Your Utility Vehicle
Towing Loads WARNING: A loaded cargo box can be very heavy. Do not attempt to dump a loaded cargo box unless vehicle is equipped with an WARNING: To help prevent personal injury electric lift option. due to loss of control or tipping, always tow a load slowly enough to maintain control. - Page 13 Engine • Clean terminals and battery cable ends with wire brush until bright. Read the Engine operator’s manual for any service or • Apply petroleum jelly or silicone spray to terminals maintenance information pertaining to the engine. to prevent corrosion. Filling Fuel Tank •...
-
Page 14: Tire Pressure
Replacing Headlights Wheel Replacement Headlights WARNING: Using an unstable lifting device The headlights are held in place by a rubber seal and vehicle support may result in bodily injury. around the perimeter of the headlight which creates a Use a safe lifting device and supports to work snug fit onto the fender. - Page 15 Clean area around opening before removing • Add approximately 189 oz (5.5 liters) of Shell TTF- dipstick. SB Oil (Cub Cadet Part No. 737-3120 or 737-3121). • Check oil level by screwing dipstick fully into • Remove dipstick located on the top of the transaxle transaxle and then remove to check level.
-
Page 16: Drive Belt
Drive Belt Adjusting Brake The wet brake system is an internal part of the WARNING: Fingers or loose clothing can get transmission and it is adjusted externally without caught in rotating parts. Stop engine and wait opening the transmission. There are two sets of brakes for all moving parts to stop before servicing. - Page 17 Adjusting Throttle Pedal • Apply light coat of oil to pivot and wear points to prevent rust. The throttle pedal assembly can be adjusted for comfort • Lubricate grease points. slightly higher or lower by lining up the holes of the •...
-
Page 18: Service Chart
Canopy W/ 4 Post Frame 39A-108-100 equipped on your vehicle. If they are not equipped, they 72” Snow Blade (Requires 115 Bracket) 39A-109-100 may be ordered through your local Cub Cadet service 225 Lb. Spreader (Requires 111 Kit) 39A-110-100 dealer. Spreader Mounting Kit... -
Page 19: Specifications
SECTION 7: SPECIFICATIONS Engine and Electrical Make Kohler 20 HP Type 4-Cycle Gas Cylinders Valves Overhead Displacement 38 cu. in. (624cc) Maximum Torque 32.6 lb-ft @ 2600 rpm Ignition Transistor Controlled Lubrication Full Pressure Oil Filter Replaceable (standard) RPM, idle (no load) 1250 ±... -
Page 20: Troubleshooting
Battery will not take a Dead battery. charge Loose or corroded connections. Sulfated or worn-out battery. Fluid level low. NOTE: For repairs beyond minor adjustments or corrections, contact your nearest Cub Cadet service dealer or call 1-877-282-8684. - Page 21 NOTES...
- Page 22 NOTES...
-
Page 23: Commercial Warranty
CUB CADET CORPORATION MANUFACTURER’S ONE YEAR LIMITED WARRANTY (COMMERCIAL USE) The limited warranty set forth below is given by CUB CADET CUB CADET does not extend any warranty for LLC (“CUB CADET”) with respect to new merchandise products sold or exported outside of the United... -
Page 24: Residential Warranty
MANUFACTURER’S LIMITED WARRANTY FOR: (RESIDENTIAL USE) The limited warranty set forth below is given by Cub Cadet possessions and territories, except those sold through LLC with respect to new merchandise purchased and used in Cub Cadet’s authorized channels of export the United States, its possessions and territories.
